Skip to content

Ruppert Marketing

  • Home
  • About Us
  • Our Services
    • Websites & Sales Funnels
    • SEO
    • PPC Marketing
    • Video Marketing & Digital Ads
    • Content Marketing
  • Our Clients
  • Free Report
Get a Quote


Installation Checklist

After installing the water heater, review the following checklist. You should be able to answer "Yes" to all of the items in the checklist. If not, review the appropriate sections to complete the installation. To troubleshoot any operational problems refer to "Troubleshooting" in the Owner's Manual. If you have additional questions or need assistance with installation, contact Technical Support at 1-800-519-8794 or 1-949-420-0420, or refer to the technical support section of Navien's website (www.navien.com).

Installing The Water Heater

Have you maintained the required clearances from building openings and intake air vents?

Have you minimized the distance between the water heater and the vent termination?

Have you minimized the distance between the water heater and major fixtures?

Have you maintained the proper service and maintenance clearances?

Is the make-up air supply sufficient for proper operation?

Is the make-up air supply free from dust, dirt, corrosive elements, and flammable vapors?

Is the water heater and vent piping clear of combustible materials, including clothing, cleaning materials, and rags?

Connecting the Gas Supply

Does the gas supply match the type specified on the water heater's rating plate?

Is the gas line at least½ in or¼ in ID (Inner Diameter)?

Is the gas supply line sufficient in length and diameter to deliver the required BTUs? *

Have you measured the pressure of the gas supply line? *

Is the gas supply pressure within the recommended ranges specified in the manual? *

Is the gas supply line equipped with a manual full port valve? *

Have you tested the gas line pressure and all fittings for leaks? *

Has the gas company inspected the installation, if required? *

Connecting the Water Supply

Is the water supply pressure sufficient (greater than 40 PSI)? *

Have you installed shut off valves on the inlet and outlet to facilitate cleaning of the inlet water filter? *

Have you bled the air out at each fixture? *

Have you checked each fixture to ensure hot water is being supplied? *

Have you cleaned the inlet water filter? *

If you installed a recirculation line, have you insulated the hot water pipes and the return line? *

Connecting a Pressure Relief Valve

Have you installed an approved pressure relief valve on the water heater? *

Does the rating of the pressure relief valve match or exceed the maximum BTU rating of the water heater? *

Is the pressure relief valve at least¼ in in diameter? *

Have you installed the pressure relief valve on the hot water outlet pipe near the water heater? *

Have you installed a discharge drain tube from the pressure relief valve to within 6-12 inch off the floor? *

Connecting the Condensate Drain

Have you installed a condensate drain line from the water heater to a drain or laundry tub? *

Venting the Water Heater

Have you vented the water heater with 2 in or 3 in PVC, CPVC, Polypropylene, Type BH Special Gas Vent (ULC-5636) for Category IV Water Heaters (Canada), or in accordance with all local codes and the guidelines in the manual? *

Have you ensured that PVC cellular core pipe has not been used as venting for the water heater? *

Is the vent sloped upward toward the vent termination at a rate of ¼ in per foot (2 % grade)? *

Are all vent runs properly supported? *

Have you properly supported the vent termination? *

Have you properly sealed all air intake and exhaust joints, from the flue collar to the to the vent termination? *

Have you installed end caps on the exhaust and intake pipes? *

Have you checked the venting for leaks? *

Is the vent termination at least 12 in (300 mm) above the exterior grade? *

Have you ensured that sufficient make-up air is available? *

Is the total vent length within the maximum vent length restriction? *

Connecting the Power Supply

Is the supplied voltage 110-120 V AC? *

Is the water heater plugged into a properly grounded outlet? *

If you have made a direct power supply connection, have you installed a power switch to facilitate end-user maintenance? *

Have you checked the polarity of the electrical connection? *

Is the system properly set up for cascade operation (master and slave water heaters), if applicable? *

Setting the DIP Switches

Have you verified the positions of all DIP switches on the circuit board? *

Have you verified the positions of all DIP switches on the front panel? *

Operating the Water Heater

Have you shown the owner how to clean the inlet water filter? *

Have you given the Installation Manual and Owner's Manual to the owner for future reference? *

Have you shown the owner how to shut off the gas in case of an emergency? *

what our clients have to say

“Their website designs are stunning, and they do things differently from the other agencies that offer web development. I had my real estate website made and it looks spectacular and has a different feel and vibe that impresses my customers."
Sophie LeonardCEO shark
Sophie Leonard
“Had my eCommerce website made by Astron Digital Marketing and I am amazed at the quality of work they did on it. It looks amazing, it’s easy to use and clear. The graphics are popping out and the image quality is top-notch!"
Herman NortonStudio Director
Herman Norton
“I love their design choices. They really did a great job on my portfolio website. After that, I can definitely say that Astron Digital Marketing is a top recommendation if you want a beautiful website. After sharing it on social media, I got lots of likes!"
Amanda ParksCYBERO
Amanda Parks

Contact Us

If you have any questions, feel free to submit our form below. We will get back to you as soon as possible.

  • 720-408-7078
  • Charles@RuppertMarketing.com

Ruppert Marketing

Our company’s philosophy for achieving success is having personalized and transparent relationships with our clients. We are always more than fair with our clients and only pursue Win-Win partnerships. When you grow, we grow!

CONTACT US

  • Phone: 720-408-7078
  • Charles@RuppertMarketing.com
Facebook Instagram Twitter Youtube Pinterest

Navigation

  • Home
  • About Us
  • Our Services
  • Our Clients
  • Contact Us

Address

  • 10818 Milliken St.
  • Parker, Colorado 80134

Hours

  • Monday – Friday: 9:00 a.m. – 4:30 p.m
  • Saturday/Sunday: CLOSED
  • © 2021 Ruppert Marketing. All Rights Reserved.